Livestock Research for Rural Development 25 (7) 2013 Guide for preparation of papers LRRD Newsletter

Citation of this paper

Effects of cocoa pod husk bioconversion with Phanerochaete chrysosporium and or Pleurotus ostreatus on its nutrient content and in-vitro digestibility in ruminants

Syahrir, Hartutik*, Kusmartono* and Damry

Faculty of Animal Science and Fishery, Tadulako University, Palu 94117, Indonesia
damry_01@yahoo.com
* Faculty of Animal Science, Brawijaya University, Malang 65145, Indonesia

Abstract

This study was designed to investigate effects of bioconverting cocoa pod husk with Phanerochaete chrysosporium and or Pleurotus ostreatus on its nutrient contents and in-vitro digestibility in ruminants. Dried and ground cocoa pod husk was mixed with rice bran,  CaCO3, and urea and sterilized by autoclaving. Sterilized cocoa pod husk was innoculated then with P. chrysosporium (0, 4, or 8 mg/kg) and or P. ostreatus (0, 15, or 30 mg/kg) in a 3 x 3 factorial experimental design resulting in nine treatment combinations, each of which was replicated three times. The fungi were allowed to ferment the cocoa pod husk and this was followed with proximate and fibre analyses on the cocoa pod husk to assess changes in its nutrients due to fermentation. An in-vitro digestibility test study was also done to investigate effects of the fermentation on the digestibility in ruminants digestive tracts.

Results indicated that the fungi did not change dry matter or organic matter contents of the cocoa pod husk. Either fungi increased crude protein content of the cocoa pod husk, and both microorganisms acted sinergetically to reduce that of crude fibre. An interaction effect was also found in the reduction of neutral detergent fibre and lignin content of the cocoa pod husk, but the highest reduction was found for the highest inclusion levels of the fungi in this study. Similarly, the highest combination levels of P. chrysosporium and P. ostreatus in fermenting cocoa pod husk tested in this study produced the highest in-vitro digestibility.

Keywords: agricultural waste, fermentation, lignin, white rot fungi


Introduction

Cocoa is an important plant in Indonesia, and the country is the second largest producer of cocoa beans in the world after Ivory Coast (FAOStat 2012). This indicates that a large quantity of cocoa pod husk is also produced in the country as a by-product. The total area of cocoa plantation in 2011 was about 1,68 million hectars (Agricultural Ministry 2012) which is equivalent to at least 4,54 million tonnes of dried cocoa pod husk. 

Currently, cocoa pod husk produced from cocoa agriculture industry remains a waste. In fact, this biomass is a potential feed resource for ruminants which are equipped with rumen microorganisms capable of degrading coarse and fibre-containing substrates (Preston and Leng 1987). However, cocoa pod husk is characterized with high contents of crude fibre and lignin and low content of crude protein (Marsetyo 2008). These low nutritional properties of cocoa pod husk limit its utilization as an animal feed without appropriate treatments to increase its nutritional quality and digestibility in animals. 

Phanerochaete chrysosporium  and Pleurotus ostreatus, are two white rot fungi species that have gained increasing attention in biological treatment of organic materials containing high levels of crude fibre and lignin. These microorganisms produce ligninases which attack the lignin component of a substrate whereby reducing the molecular complex of ligno-cellulose. P.  chrysosporium produces peroxidases, i.e. lignin peroxidase (LiP) and manganese peroxidase (MnP), while P. ostreatus produces Laccase in addition to the two peroxidases (Rothschild et al 1999)

While the two fungi have been used as biological agents to de-lignify a range of lignified substances separately, little is known on the lignifying effects of the two fungi when used simultaneously. In particular, no research has been done which use both the fungi simultaneously in bioconversion of agricultural by-products such as cocoa pod husk. This study was therefore designed to investigate effects of P. chrysosporium and P. ostreatus, alone or in combination, on changes in nutrient content of cocoa pod husk and its in vitro digestibility in ruminant animals.   


Materials and Methods

Fermentation of cocoa pod husk

 

Dried and finely ground cocoa pod husk (10kg) was mixed with rice bran (1.5kg), CaCO3 (0.15kg), urea (10g) and water (70% of the total weight) and mixed thoroughly. The mixture was put into polypropilene bags (1kg for each bag), sealed properly and the mixture-containing bags were sterilized by autoclaving at 121°C and 2 atm for 1h, and followed with cooling them at the room temperature for 24–36h. The sterilized cocoa pod was then innoculated with either Phanerochaete chrysosporium (107cells/g) and or Pleurotus ostreatus (14.3 x 109cfu/ml) according to the respective treatment level. The bags were placed in a room at a temperature of 25–30°C and air humidity of 80–90% to allow the fungi to grow. When the cocoa pod mixtures inside the bag were completely covered with mycelium, the incubation was terminated and the bags were opened. 

 

Experimental

The fermentation experiment was done in a 3x3 factorial design with P. chrysosporium level (0, 4, or 8 g/kg) as the first factor and P. ostreatus level (0, 15, or 30 g/kg) as the second factor. This resulted in the following nine treatment combinations, each of which was replicated three times:

Pc1Po1         =              Cocoa pod without fermentation

Pc1Po2         =              Cocoa pod +  P.  ostreatus (15g/kg)

Pc1Po3         =              Cocoa pod + P.  ostreatus (30g/kg)

Pc2Po1         =              Cocoa pod + P.  chrysosporium (4g/kg)

Pc2Po2         =              Cocoa pod + P.  chrysosporium (4g/kg) + P.  ostreatus (15g/kg)

Pc2Po3         =              Cocoa pod + P.  chrysosporium (4g/kg) + P.  ostreatus (30g/kg)

Pc3Po1         =              Cocoa pod + P.  chrysosporium (8g/kg)

Pc3Po2         =              Cocoa pod + P.  chrysosporium (8g/kg) + P.  ostreatus (15g/kg)

Pc3Po3         =              Cocoa pod + P.  chrysosporium (8g/kg) + P.  ostreatus (15g/kg)

 

Parameters observed were changes in dry matter, organic matter, crude protein, and crude fibre contents of the cocoa pod husk. Proximate analysis was done using standard procedures (AOAC 1990) while fibre component analysis (neutral detergent fibre, acid detergent fibre) was done according to Goering and van Soest (1987). Hemicellulose content was calculated as the difference between neutral detergent fibre contents with those of acid detergent fibre, while cellulose was taken as the acid detergent fibre minus lignin.

 

In vitro dry matter and organic matter digestibility of cocoa pod husk was carried out according to Tilley and Terry (1963) as modified by van der Meer (1980). Strained rumen fluid for the in vitro digestibility study was obtained from a rumen cannulated steer daily ration of 3 kg concentrate feed (a mixture of pollard, coconut meal, ground maize, premix, and mineral) and King grass ad libitum.


Results and Discussion

This study indicated that Phanerochaete chrysosporium or Pleurotus ostreatus did not affect dry matter or organic matter contents of cocoa pod husk. However, either P. chrysosporium or P. ostreatus increased the crude protein concentrations of the cocoa pod husk with the higher increase observed for higher levels of fungi application. On the other hand, a reduction was observed for crude fibre concentrations of cocoa pod husk after fermentation, and the two fungi acted sinergetically to affect this parameter.

Table 1: Dry matter, organic matter, crude protein and crude fibre contents of cocoa pod husk fermented with Phanerochaete chrysosporium (Pc) and or Pleurotus ostreatus (Po)

Nutrients (%)

Phanerochaete chrysosporium

Pleourotus ostreatus

Means

SEM
(p value)

Po1

Po2

Po3

Dry matter

Pc1

88.8

87.4

87.3

87.9

 

Pc2

88.2

88.0

87.8

88.0

 

Pc3

88.1

87.8

87.5

87.8

 

Means

88.3

87.7

87.6

 

 

Organic matter

Pc1

78.3

77.4

77.4

77.7

 

Pc2

77.9

76.7

76.6

77.1

 

Pc3

78.0

76.6

76.3

76.9

 

Means

78.1

76.9

76.8

 

 

Crude protein

Pc1

6.87

7.32

8.10

7.43x

0.44(0.001)

Pc2

8.89

9.44

10.0

9.46y

Pc3

9.20

10.4

10.6

10.1z

Means

8.3A

9.04B

9.59C

 

 

SEM (p value)

0.18(0.001)

 

 

         

Crude fibre

Pc1

44.0a

38.7b

38.6b

40.5x

 

Pc2

38.3b

36.1c

35.0cd

36.5y

Pc3

36.8d

33.7e

33.1e

34.4z

Means

39.7A

36.0B

35.6B

 

SEM (p value)

0.41 (0.007)

   

(A-B)   Different superscript letters indicate significant difference for P. chrysosporium

(a-e)    Different superscript letters indicate significant difference for P. chrysosporium and P. ostreatus

(x-z)    Different superscript letters indicate significant difference for P. ostreatus

Increased proportions of crude protein when fermented with P. chrysosporium or P. ostreatus is a common observation reported previously in some studies (Nelson and Suparjo 2011;  Laconi 1998). However, such a phenomenon has to be interpreted cautiously as this not an indication of a nutritional improvement as a result of new true protein synthesis. In the current study, the increased crude protein concentrations was merely due to oxidation of dry matter during fermentation and to nitrogen contributed by the addition of rice bran (12% crude protein), urea and the fungi itself.  

This study demonstrated that both fungi acted sinergetically in reducing the crude fiber contents of the cocoa pod husk (Table 1) and this can be attributed mainly to the reduction of neutral detergent fibre. It is known that both fungi produce fibre-degrading enzymes (Howard et al 2003) which degrade the fibre component of the fermented substrates. Reduction in lignin content of a substrate is the main feature of using P. chrysosporium or P. ostreatus a bioconverter of feed materials containing lignin. Van Soest (2006) stated that white rot fungi are effective agents to reduce the lignin content of a feed. Lignininase of P. chrysosporium has been described as an extracelullar enzyme which is secreted during nutrient starvation such as of nitrogen and carbon (Tien and Kirk 1988).

Table 2: Neutral detergent fibre, acid detergent fibre, cellulose, hemicellulose and lignin contents (%) of cocoa pod husk fermented with Phanerochaete chrysosporium and or Pleurotus ostreatus

Fibre Components

Phanerochaete chrysosporium

Pleurotus ostreatus

Means

SEM
(p value)

Po1

Po2

Po3

Neutral Detergent Fibre

Pc1

76.7a

71.7b

71.4b

76.7x

 

Pc2

71.7b

70.9bc

69.4d

70.7y

Pc3

69.4cd

67.7e

67.4e

68.14z

Means

72.6A

70.1B

69.4B

 

SEM (p value)

0.54 (0.007)

 

 

Acid Detergent Fibre

Pc1

57.2

55.9

55.8

56.3x

0.89 (0.005)

Pc2

56.4

55.6

54.9

55.6x

Pc3

55.7

53.7

54.4

54.6y

Means

56.4A

55.1B

55.0B

 

 

SEM (p value)

0.27 (0.001)

 

 

Cellulose

Pc1

33.1

32.6

32.2

32.6x

0.70 (0.025)

Pc2

32.7

32.5

32.5

32.6x

Pc3

32.4

31.3

30.2

31.3y

Means

32.8A

31.9B

31.7B

 

 

SEM (p value)

0.19 (0.008)

 

 

Hemicellulose

Pc1

19.5

15.8

15.6

17.0x

0.59 (0.044)

Pc2

15.3

15.2

14.6

15.0y

Pc3

13.8

13.7

13.5

13.6z

Means

16.2A

14.9B

14.5B

 

 

SEM (p value)

0.26 (0.003)

 

 

Lignin

Pc1

26.00a

21.9b

21.3b

23.1x

 

Pc2

21.4b

20.4b

19.2c

20.4y

 

Pc3

21.0b

18.8cd

18.7d

19.5y

 

Means

22.8A

20.4B

19.8B

 

 

SEM (p value)

0.41 (0.008)

 

 

(A-B)   Different superscript letters indicate significant difference  for P. chrysosporium

(a-e)    Different superscript letters indicate significant difference for P. chrysosporium and P. ostreatus

(x-z)    Different superscript letters indicate significant difference for P. ostreatus

Reduction in fibre and lignin components of the fermented cocoa pod in this study was followed with an increase in in vitro dry matter or organic matter digestibility (Table 3). The highest digestibility was observed for the cocoa pod that had been fermented by both fungi indicating a greater accessibility for rumen microbes to degrade this substance compared to those were not fermented or fermented by individual fungus.  

Table 3: In vitro dry matter and organic matter digestibility (%) of cocoa pod husk fermented with Phanerochaete chrysosporium and or Pleurotus ostreatus

Nutrient Digestibility

Phanerochaete chrysosporium

Pleurotus ostreatus

Means

Po1

Po2

Po3

Dry matter

Pc1

39.2a

42.4b

43.9c

41.8x

Pc2

43.3bc

46.0d

48.0e

45.8y

Pc3

47.3e

48.3ef

49.2f

48.3z

Means

43.3A

45.5B

47.0C

 

SEM (p value)

0.64 (0.008)

 

       

 

Organic matter

Pc1

41.7a

41.8a

42.6ab

42.0x

Pc2

42.0a

43.4b

46.2c

43.9y

Pc3

45.9c

48.3d

48.4d

47.5z

Means

43.1A

44.5B

45.8C

 

SEM (p value)

0.53 (0.021)

 

(A-B)   Different superscript letters indicate significant difference for P. chrysosporium

(a-e)    Different superscript letters indicate significant difference for P. chrysosporium and P. ostreatus

(x-z)    Different superscript letters indicate significant difference for P. ostreatus


Conclusions


References

Agricultural Ministry 2012 Statistics of Estate Plantation. Jakarta, Indonesia. 

AOAC 1990 Official Methods of Analysis, 15th Edition. Association of Official  Analytical Chemists, Arlington, VA. pp. 1298. 

FAOStat 2012 Food and Agriculture Commodities Production. Food and Agriculture Organization of the United Nations. Retrieved April 20, 2013 from http://faostat.fao.org/site/339/default.aspx

Goering H K and van Soest V J 1970 Forage fiber analysis (apparatus, reagents, procedures, and some applications). USDA Agricutural Research Service. Handbook number 379. 

Howard R T, Abotsi E, Jansen van Rensburg E L and Howard S 2003 Lignocellulose biotechnology: issue of bioconversion and enzyme production. African Journal of Biotechnology 2; 602 -619. 

Laconi E B 1998 Peningkatan kualitas kakao melalui amoniasi dengan urea dan biofermentasi dengan Phanerochaete chrysosporium serta penjabarannya dalam formulasi ransum ruminansia. Disertasi. Program Pascasarjana Institut Pertanian Bogor, Bogor

Marsetyo 2008 Pemenuhan pakan untuk meningkatkan produkstivitas dan populasi ternak potong.  Prosiding Seminar Nasional Sapi Potong,  Palu. 

Nelson dan Suparjo 2011  Penentuan lama fermentasi kulit buah kakao dengan Phanerochaete chrysosporium - evaluasi kualitas nutrisi secara kimia. Agrinak  01: 1-10. 

Preston T R and  Leng R A 1987 Matching Livestock Production Systems in the Tropics and Sub-tropics with Available Resources. Penambul Books, Armidale, NSW. http://utafoundation.org/P&L/preston&leng.htm

Rothschild N, Levkowitz A, Hadar Y and Dosoretz C G 1999 Manganese deficiency can replace high oxygen levels needed for lignin peroxidase formation by Phanerochaete chrysosporium. Applied and Environmental Microbiology 65: 483-488

Tien M and Kirk T K 1988. Lignin Peroxidase of Phanerochaete chrysosporium. In: W A Wood and S T Kellogg, eds. Methods in Enzymology-Biomass, Part B, Lignin, Pectin, and Chitin. Academic Press, Inc., San Diego, CA,  pp. 238-249. 

van der Meer J M 1980 Determination of the in vitro digestibility for the prediction of the in vivo organik matter digestibility coefisient of  feeds for ruminants.  Instituut voor Veevoedingsonderzoek. Hoorn, the Netherland. 

van Soest P J 2006 Rice straw, the role of silica and treatments to improve quality. Journal of Animal Feed Science and Technology 130: 137–171. 


Received 12 May 2013; Accepted 14 June 2013; Published 1 July 2013

Go to top