Livestock Research for Rural Development 23 (8) 2011 Notes to Authors LRRD Newsletter

Citation of this paper

Forage conservation and profitable smallholder milk production in Honduras

C Reiber, M Peters* and R Schultze-Kraft*

University of Hohenheim, Institute of Plant Production and Agroecology in the Tropics and Subtropics, University of Hohenheim,
Stuttgart, Germany
chreiber@gmx.de
* CIAT (International Center for Tropical Agriculture), Cali, Colombia

Abstract

In the seasonally dry tropics of  Honduras, common strategies to overcome dry-season feed constraints include supplementation with commercial concentrate and/or maize silage. However, these supplements are considered expensive by smallholders. The aim of this study was to evaluate (1) the effect of substituting part of supplemented commercial concentrate (CC) by farm-produced cowpea hay (CH, Experiment 1a) and cowpea grain concentrate (CGC, Experiment 1b), and (2) the effect of substituting maize silage (MS) by silage of the grass, Brachiaria brizantha cv. Toledo (TS, Experiment 2a), and of sorghum (SS, Experiment 2b) on milk yield and profitability measured as income over feed costs (IOFC) per cow and day. All experiments were carried out in collaboration with farmers and used change-over designs, involving balanced groups of crossbred cows.

 

Results of Experiment 1a revealed non-significant differences between treatments for milk yield and IOFC. However, the trend indicated that the slightly lower revenue in the CH treatment was more than compensated by its lower costs compared to the CC treatment. Results of Experiment 1b showed 0.58 kg/cow higher milk yield with CC treatment. However, IOFC was higher for CGC (1.47 $US) compared to CC treatment (1.26 $US).

 

Results of Experiment 2a revealed similar milk yield and IOFC for both treatments. However, the slightly lower milk yield with the TS treatment was more than compensated by lower feed costs compared to the MS treatment. Results of Experiment 2b showed significantly higher milk yield (11.32 kg/cow) and IOFC (2.17 $US) of SS compared to MS treatment (8.76 kg/cow; 1.54 $US).

 

Farm-produced conserved forages such as CH and CGC as well as TS and, particularly, SS proved efficient as (partial) substitutes for CC and MS, respectively, and should be further promoted as low-cost and high-quality conserved forage options for smallholders.

Key words: Cowpea grain concentrate, cowpea hay, grass silage, income over feed costs, participatory on-farm feeding trials


Introduction

Feed shortage during the five to six months of dry season in many areas of Honduras severely limits livestock production, farm productivity and smallholder income (Lentes et al 2010a). Common strategies to overcome feed constraints and maintain milk production during the dry season include supplementation with high levels of commercial concentrate (Lentes et al 2010b) and/or feeding of maize silage (Reiber et al 2010). These strategies, however, are considered expensive by smallholders. The use of alternative conserved forage from legumes and grasses promises higher returns per litre of milk (Holmann and Lascano 2004, Nakiganda et al 2005) but is rarely applied by smallholders in the tropics (Shelton et al 2005, Mannetje ‘t 2000).

 

The conservation of adapted forage legumes such as cowpea (Vigna unguiculata) and grasses such as Brachiaria brizantha cv. Toledo and sorghum have been promoted in Honduras during farmer trainings and field days in the framework of a research project carried out by CIAT (Centro Internacional de Agricultura Tropical) in collaboration with national partners and the University of Hohenheim. Therein, on-farm experiments were conducted in collaboration with farmers in order to evaluate the potential of conserved-forage options under smallholder conditions.

 

The objective of this study was to evaluate the effect of (1) partially substituting commercial concentrate by cowpea (Vigna unguiculata) hay (Experiment 1a) and cowpea grain concentrate (Experiment 1b), and (2) substituting maize silage by B. brizantha cv. Toledo silage (Experiment 2a) and sorghum silage (Experiment 2b) on milk yield, body weight (BW) change, revenue and profitability measured as income over feed costs (IOFC). IOFC is a proven financial measurement to monitor the profitability of a dairy operation (Penn State University 2009).

 

 

Materials and Methods

 

Location

 

The experiments were conducted on four farms in Victoria and Sulaco, department of Yoro, Honduras, during February-April in the 2006 dry season. The farms are located at altitudes of about 400 m a.s.l. Average temperature ranges from about 22 °C in the coldest month January to about 27 °C in the hottest months April and May. Average annual precipitation ranges from about 1000 mm in Sulaco to 1150 mm in Victoria. The dry season usually begins in November and lasts up to 6 months.

 

Production of silage and hay

 

Fresh matter production of cowpea (variety IITA 284/2) was approximately 18 tons/ha. An area of 3600 m² of cowpea was cut for hay in the early flowering stage (mid November). The first day, it was sun-dried. The second day, for further drying and in order to prevent leaf losses in the field, it was hung underneath a roof with open sides. About 1.2 tons of cowpea hay was harvested of which about 0.46 tons were used for the experiment.

 

The pasture grass Toledo was fertilized with 65 kg of urea (46% nitrogen) per ha. About 5 tons of Toledo from an area of about 3500 m² were cut in December after 32 days of re-growth. After one day of dehydration in the field and chopping to a particle size of 8 to 10 cm, it was ensiled in a pit silo. About 10% of chopped forage sugarcane was added in layers as additive to support the fermentation process with water-soluble carbohydrates.

 

Maize (local commercial variety) and sorghum (Christiani, HF 802 hybrid) were cut for silage at milky to doughy stage of maturity and ensiled in a bunker and heap silo, respectively. No additives were used. 

 

Selection of cows


Criteria for the selection of the cows were a lactation period of more than two months at the time of the experiment, similar milk yield, weaned calves, number of calvings between two and six, and similar BW and body condition scores (BCS) according to Elanco Animal Health (1997) (Table 1). Cows represented regionally common crossbred animals with a Bos taurus share of 25% to 62.5%.


Table 1. Characterisation of cows in the experiments

Experiment:

1a

1b

2a

2b

Number of cows

8

6

6

3

Number of calvings

2-4

2-6

2-3

3-5

BCS1

3.5-4.0

2.75-3.0

2.75-3.5

3.5

BW (kg)

373-552

293-409

377-493

361-452

Crosses2

On average:

Br 3/8 x BS 3/8 x Ho 1/4

On average:

Br 1/2 x BS 1/2

4 cows:

Br 1/2 x Si 1/2;

2 cows:

Br 3/4 x BS 1/4

3 cows:

Br 3/8 x BS 5/8

1BCS 2.75 indicates “skinny”, BCS 4.0 indicates “fleshy”; 2Br = Brahman, Ho = Holstein-Friesian, BS = Brown Swiss, Si = Simmental


Experimental designs

 

The experiments were conducted using change-over (reversal) designs of switch-back and rotational (Latin square) types (Lucas 1960) (Table 2). A feeding period consisted of an adaptation phase of 3-7 days and the subsequent measurement phase of seven days.


Table 2. Characterisation of experiments

Experiment:

1a

1b

2a

2b

Design classification (type)

Switch-back

Latin square

Switch-back

Switch-back

Number of groups

2

2

2

1

Cows per group (no.)

4

3

3

3

Duration of experiment (no. of days)

42

30

42

30

Number of feeding periods

3

2

3

3

Days per feeding period (no.)

14

10

14

10

Days per adaptation phase (no.)

7

3

7

3

Days per measurement phase (no.)

7

7

7

7


Data collection

 

Depending on the farm and the number of milkings, milk yield for each cow was recorded once or twice daily using a digital scale. For Experiments 1a and 2a, BW was measured every seven days, at the beginning and at the end of each measurement period using a portable digital livestock balance. BW measurements were always done at the same time of the day (immediately after morning milking) to avoid BW changes due to differences in the degree of rumen and udder fill.

 

Costs of supplemented feed components were enquired using a structured questionnaire. In the experiments where cows had also access to grass pastures for grazing, the costs of the grazed pastures were not considered.

 

Feed rations and treatments

 

Experiment 1a:

The farmer decided upon the feed rations. The feed was supplemented in two rations, one in the morning and one in the afternoon during milking. Cows did not graze during the experiment. The basic feed ration (BFR) was maintained during the whole experiment and was the same for all cows, consisting of 9.1 kg maize silage (35.3% dry matter, DM) + 13.6 kg sugarcane (25% DM) + 6.8 kg maize straw (90% DM).

 

Based on the farmer’s suggestion to substitute part of the commercial concentrate (CC) (1.8 kg; 22% crude protein, CP) by a protein equivalent amount of cowpea hay (2.73 kg; 16.2% CP), the following treatments were applied:

 

Treatment CH (cowpea hay): BFR + 3.64 kg CC + 2.73 kg CH

Treatment CC (commercial concentrate): BFR + 5.45 kg CC

 

Experiment 1b:

Basic feed ration (BFR): 12.3 kg silage (mix of 85% sorghum, 7.5% maize and 7.5% cowpea foliage) + grazed pasture (Brachiaria brizantha cv. Toledo)

 

Treatment CGC (cowpea grain concentrate): BFR + 1.4 kg CC (“Maintenance”, min 12% CP) + 1.4 kg ground maize + 1.4 kg ground cowpea grain

Treatment CC (commercial concentrate): BFR + 4.1 kg CC (“Lechera Nutricia”, min 20% CP)

 

Experiment 2a:

The cows were fed on a time-restricted ration of maize silage (MS) and Toledo silage (TS) from 9 am to 2 pm. Thereafter, cows grazed on Andropogon gayanus and Brachiaria hybrid cv. Mulato pastures. During the first days of the initial adaptation phase, the quantity of silage offered was adjusted to ensure maximum intake and then maintained throughout the experiment.

BFR: 2.6 kg CC (min 20% CP) + pasture

Treatment MS: 13.6 kg fresh matter (FM) of maize silage

Treatment TS: 12.5 kg FM of Toledo silage

 

Experiment 2b:

Sorghum silage (SS) and maize silage (MS) were offered in the morning from 5.00 to 11.30 am and in the afternoon from 3.00 to 4.30 pm (time restricted supplementation).

BFR: 2 kg CC (min 20% CP) + pasture (B. brizantha cv. Toledo) grazing

Treatment SS: Sorghum silage (ad libitum)

Treatment MS: Maize silage (ad libitum)

 

Analysis of forage quality

 

Silage samples were taken along in a cooler for laboratory analyses of pH, CP, neutral detergent fibre (FDN), ether extract and ash. Analyses were done following standard procedures according to the Association of Official Analytical Chemists methodologies (AOAC 1990). Additionally, silage fermentation quality was assessed by evaluation of smell, colour and texture according to ÖAG (1999).

 

Statistical analyses 

For statistical analysis of milk yield, revenue and IOFC, only data from the measurement phase were considered. IOFC was calculated by subtracting total feed costs from revenue from milk sales, according to the following formula: IOFC ($US/cow/day) = milk price ($US/litre) x milk yield (kg/cow/day) – total feed costs ($US/cow/day), using a dry season milk price of 0.29 $US/litre and considering one litre of milk as one kg and vice versa. Thus IOFC is a linear transformation within a treatment.  

Data were processed using IBM SPSS Statistics 19 Software (2010). The data were subjected to analysis of linear mixed model procedures based on the following equation adapted from Tempelman (2004):
 

Yijkl = μ + αi + βj + ck + gl + (αβ)ij + (αc)ik + eijk


Where;   Yij k  =  Dependent variable (milk yield, revenue, IOFC and weight change)

                 μ    =  Overall mean

                 αi   =  Effect of ith treatment

                 βj     =  Effect of jth feeding period

                 ck   =  Effect of kth cow 

               (αβ)ij = Effect of ith treatment * jth feeding period interaction

               (αc)ik = Effect of ith treatment * kth cow

                eijk    =  Error effect

 

The factors treatment and feeding period including their interaction treatment * feeding period were treated as fixed effects whereas cow and its interaction cow * treatment were treated as random effects. It was assumed that repeated measurements for milk yield within a period were correlated, but observations of different cows were assumed to be uncorrelated. A model assuming that residuals had an autoregressive variance-covariance structure with one factor (AR1) was found to fit well to the data. Additionally, effects of treatments were tested for significance using the F-test. In the case of only two stages of a factor, the result is identical to that of a t-test, by which differences between least square means (LSM) are tested.

 

For the analysis of Experiment 1b, the random effect treatment * cow was excluded from the model according to analysis of replicated Latin square designs as shown by Tempelman (2004). For the analysis of Experiment 2b, the effect of the treatment * feeding period interaction was confounded with the period effect and therefore dropped from the model. The remaining period effect includes both the period effect and its interaction effect with treatment.

 

 

Results

 

Experiment 1a: Partial substitution of commercial concentrate (CC) by cowpea hay (CH)

 

Feed intake and quality
 

Cows consumed 100% of the offered BFR (Table 3). Cowpea hay had a CP content of 16.2%, the commercial concentrate a CP of 22% (data not shown). On average, daily DM intake was 3.5% of BW.


Table 3. Total feed intake in kg DM/cow/day

 

BFR

Cowpea hay 

Concentrate

Total DM intake

Treatment CH (cowpea hay)

11.4

2.3

3.2

16.9

Treatment CC (commercial concentrate)

11.4

0.0

4.8

16.2

5.45 kg of commercial concentrate (88% DM) corresponds to 4.8 kg DM

3.64 kg of commercial concentrate (88% DM) corresponds to 3.2 kg DM

2.73 kg of cowpea hay (85% DM) corresponds to 2.32 kg DM


Feed costs
 

The costs for the feed components of the basic feed ration (BFR) totalled 0.31 $US/cow. The total feed ration (TFR) costs were 1.43 and 1.78 $US/cow for treatments CH and CC, respectively (Table 4).


Table 4. Feed costs ($US/kg and $US/cow)

 

 $US/kg

Treatment CH

($US/cow)

Treatment CC

($US/cow)

Maize silage

0.014

0.127

0.127

Sugarcane chopped

0.0081

0.110

0.110

Maize straw

0.013

0.07

0.07

Concentrate

0.27

0.98

1.47

Cowpea hay

0.05

0.14

0

Total feed costs

 

1.43

1.78


BW change, milk yield, revenue and IOFC

 

According to the overall weight averages of both groups, cows lost weight during the concentrate treatment whereas they gained weight during the cowpea hay treatment (Table 5). The difference between the treatments, however, was not significant. The trend of results showed a slightly lower milk yield but a higher IOFC with the CH treatment compared to the CC treatment (P > 0.05).


Table 5. Least square means (LSM) and their standard error (SE) of BW change, milk yield, revenue and IOFC

 

Treatment CH

Treatment CC

 SE

P1

BW change (kg/cow)

0.19

-0.59

0.432

0.230

Milk yield (kg/cow)

12.54

13.18

0.435

0.122

Revenue from milk sale ($US/cow)

3.64

3.82

0.126

0.122

IOFC ($US/cow)

2.21

2.04

0.126

0.164

1P = Probability level, P < 0.05 indicates significant differences between treatments


Experiment 1b: Partial substitution of commercial concentrate by cowpea grain concentrate

 

Feed quality and intake

 

The farm-produced cowpea grain concentrate (CGC) was composed of 33% CC (“Maintenance”, 13.8% CP), 33% ground maize (10.3% CP) and 33% ground cowpea (26.0% CP) averaging 16.7% CP. The concentrate was readily accepted by the cows. The concentrate of treatment CC (“Lechera Nutricia”) had a CP content of 22.5%.

 

Dry matter intake (DMI) of the different feed components averaged 3.7 kg for the silage mixture (as part of BFR), an estimate of 1.4 kg of pasture grass (as part of BFR) and 3.6 kg for both concentrate treatments with a total of about 8.7 kg DM/cow/day (on average 2.5% of BW).

 

Feed costs

 

Table 6 shows the costs of the feed ingredients. The total feed costs per ration were 0.38 $US/cow higher for the CC treatment than for CGC. Feed costs per kg of milk were 0.10 and 0.14 $US for CGC and CC treatment, respectively.


Table 6. Feed costs ($US/kg and $US/cow)

 

Silage

Concentrate (“Maintenance”)

 

Concentrate (“Lechera Nutricia”)

Cowpea grain

Maize grain

Total

$US/kg

0.012

0.17

0.24

0.11

0.16

 

CGC ($US/cow)

0.15

0.23

0

0.15

0.22

0.75

CC ($US/cow)

0.15

0

0.98

0

0

1.13


Milk yield, revenue and IOFC

 

Milk yield difference between CC and CGC was significant, with 0.58 kg/cow in favour of the CC treatment (Table 7). IOFC was in the CGC treatment 0.21 $US/cow higher than in the CC treatment. This means that the lower milk yield in the CGC treatment was more than compensated by lower costs.


Table 7. Least square means (LSM) and their standard error (SE) of milk yield, revenue and IOFC

 

Treatment CGC

Treatment CC

SE

P1

Milk yield (kg/cow)

7.66

8.24

0.261

0.016

Revenue from milk sale ($US/cow)

2.22

2.39

0.076

0.016

IOFC ($US/cow)

1.47

1.26

0.076

0.003

1P = Probability level, P < 0.05 indicates significant differences between treatments


Experiment 2a: Effect of substituting maize silage by Brachiaria brizantha cv. Toledo silage

 

Silage quality and intake

 

The pH value in combination with DM content indicated that Toledo grass did not ferment well (Table 8). However, this could not be confirmed through organoleptic evaluation. Both silages had a pleasant sweet odour and green colour (organoleptic mark 1 = very good).


Table 8. Silage quality

 

DM

%

pH

CP (%)

FDN (%)

Ash (%)

Ether

extract (%)

Organo-leptic mark

Maize silage (MS)

31

4

6.44

70.61

5.45

2.33

1

Toledo silage (TS)

25.6

5

5.04

73.42

9.80

1.96

1


The cows consumed all maize silage offered (13.6 kg of FM per day, equivalent to 4.2 kg/cow/day of DM). On average, 1.4 kg FM/cow/day of the offered Toledo silage was rejected. Thus, its intake turned out to be 11.1 kg FM/cow/day or 2.8 kg DM per cow. Average intake of commercial concentrate (22% CP) was 2.6 kg/cow in both treatments.

 

Feed costs

 

Feed costs/cow totalled 0.90 $US and 0.81 $US for the MS and TS treatments, respectively (Table 9).


Table 9. Feed costs ($US)

 

Silage consumed

(kg FM)

Silage costs/kg

Silage costs/cow

Concentrate

costs1/cow

 

Total feed

costs/cow

Treatment MS

13.6

0.015

0.20

0.70

0.90

Treatment TS

11.1

0.01

0.11

0.70

0.81

1 Concentrate costs: 0.27 $US/kg


BW change, milk yield, revenue and IOFC

 

Average daily BW change difference between treatments was not significant. Average body condition scores increased during the experiment from 3.79 to 4.04 and did not show any difference between treatments, thus indicating a positive energy balance of the rations. Results revealed similar milk yields of cows when supplemented with maize silage (MS) and Toledo silage (TS) (Table 10). IOFC was slightly higher for TS than for MS. This means that the lower milk yield (and lower revenue from milk sale) of TS was more than compensated by its lower cost. 


Table 10. Least square means (LSM) and their standard error (SE) of BW change, milk yield, revenue and IOFC

 

Treatment MS

Treatment TS

SE

P1

BW change (kg/cow)

0.49

-0.28

0.381

0.159

Milk yield (kg/cow)

5.55

5.43

0.406

0.671

Revenue from milk sale ($US/cow)

1.61

1.57

0.118

0.671

IOFC ($US/cow)

0.71

0.76

0.118

0.507

1P = Probability level, P < 0.05 indicates significant differences between treatments


Experiment 2b: Effect of substituting maize silage by sorghum silage

 

Silage quality and intake

 

The pH values in combination with DM contents indicated that both silages had fermented well (Table 11). This was confirmed by organoleptic evaluations of smell (pleasantly sweet, absence of butyric or strong acid smell), colour (green) and texture (intact) with an overall grade of “very good” for both silages.


Table 11. Silage quality

 

DM

(%)

pH

CP

(%)

Ether

extract (%)

NDF

(%)

Ash

(%)

Organo-leptic mark

Sorghum silage (SS)

35

4.8

7.52

2.46

85.32

7.77

1

Maize silage (MS)

30.5

4.6

7.84

2.61

75.01

7.88

1


Cows preferred sorghum silage (SS) to maize silage (MS), which was corroborated by a considerably higher intake: Intake of MS averaged 18.2 kg FM (5.6 kg DM) whereas that of SS averaged 22.8 kg FM (8.0 kg DM).

 

Feed costs

 

Table 12 shows the costs for MS and SS production. Sorghum fresh matter (FM) production was estimated at 17.1 tons/ha. Considering a 5% loss due to silage spoilage, the production costs of SS were about 0.029 $US/kg of FM. Maize FM production was estimated at 28.6 tons/ha. Considering a 5% loss due to silage spoilage, the production costs of MS were about 0.025 $US/kg of FM.


Table 12. Sorghum and maize silage production costs

 

Sorghum silage (SS)

Maize silage (MS)

 

Lps1/mz2

$US/ha

Lps/mz

$US/ha

Ploughing with tractor

800

60.2

800

60.2

Oxen for seedbed preparation

500

37.6

500

37.6

Labour for sowing

200

15.0

200

15.0

Seed

409

30.8

40

3.0

Fertilizer (urea)

0

0

1200

90.2

Fertilizer (NPK:18-46-0)

1200

90.2

1200

90.2

Labour for fertilizer application

150

11.3

150

11.3

Plant protection measures

90

6.8

90

6.8

Labour for weeding

1000

75.2

1000

75.2

Total crop production costs

4349

327.0

5180

389.5

Labour for ensiling process (harvest, transport, compaction)

1040

78.2

2347

176.5

Plastic for silo cover

200

15.0

320

24.1

Fuel for chopper

86.5

6.5

154

11.6

Chopper rent

500

37.6

889

66.8

Total costs for ensiling

1826

137

3710

279

Total silage production costs

6175

464

8890

668

1Lps = Honduran Lempiras: 19 Lps = 1 $US; 2mz (“manzana”): 1 mz = 0.7 ha


Two sorghum silage cases were considered for the calculation of IOFC: (a) SS costs of 0.029 $US/kg (only considering the first cut), and (b) the same costs for MS and SS (0.025 $US/kg). Case (b) serves to demonstrate how the higher palatability (or intake) of SS influences profitability. Total feed costs of the SS treatment were for cases (a) and (b) 1.09 $US/cow and 0.97 $US/cow, respectively, and 0.89 $US/cow for the MS treatment (Table 13). Feed costs per kg of milk were 0.096 and 0.101 $US for SS and MS treatment, respectively.


Table 13. Feed costs ($US)

 

Silage

intake (kg FM)

Silage

costs/cow

Concentrate1

costs/cow

Total feed

costs/cow

Sorghum ration

22.8

(a) 0.66

(b) 0.57

0.54

1.20 (a)

1.11 (b)

Maize ration

18.2

0.46

0.54

1.00

1 Concentrate costs: 0.27 $US/kg; Sorghum silage costs: 0.029 (a) and 0.025 (b) $US/kg


BW change, milk yield, revenue and IOFC

 

On average, cows maintained their BW during the period, when MS was supplemented, at 406 kg/cow. In the SS treatment, average BW slightly increased to 413 kg/cow. Average milk yield and revenue were significantly higher from SS than from MS, with a difference of 2.56 kg/cow and 0.74 $US/cow, respectively (Table 14). IOFC was 0.54 $US/cow and 0.63 $US/cow higher in treatment SS than in treatment MS, for scenarios (a) and (b), respectively. Results indicate that the higher feed costs of SS were more than compensated by higher milk yield.


Table 14. Least square means (LSM) and their standard error (SE) for milk yield, revenue and IOFC

 

Treatment SS

Treatment MS

P1

 

LSM

SE

LSM

SE

Milk yield (kg/cow)

11.32 

0.974

8.76

0.984

0.037

Revenue from milk sale ($US/cow)

3.28

0.282

2.54

0.285

0.037

IOFC ($US/cow) (a)

2.08

0.282

1.54

0.285

0.066

IOFC ($US/cow) (b)

2.17

0.282

1.54

0.285

0.046

1P = Probability level, P < 0.05 indicates significant differences between treatments

Discussion

Cowpea hay and cowpea grain concentrate versus commercial concentrate

 

Both experiments indicated that feed costs could significantly be reduced by substituting commercial concentrate by farm-produced feed such as conserved cowpea products while maintaing the performance of the cows. Based on the results of this study, a farmer with 10 cows could save a total of about 200 $US (Experiment 1a) and 250 $US (Experiment 1b) during a supplementation period of four dry-season months when partially substituting commercial concentrate by farm-produced cowpea hay and cowpea grain concentrate, respectively.

 

The CP content of cowpea hay (16.2%) in this study was lower than the range of 19.5-26% CP found by Ravhuhali et al (2010) and higher than 10% and 15.4% CP found by Savadogo et al (2000) and Baloyi et al (2001), respectively. The CP content of cowpea grain (26.0%) was as high as that reported by Rivas-Vega et al (2006) (26.1%). A number of studies have confirmed a positive effect of cowpea products on ruminant performance (Anele et al 2010, Akinlade et al 2005, Bartholomew et al 2003, Chakeredza et al 2002, Koralagama et al 2008, Murthy and Prasad 2002).

 

Similar to the results of this study, Kiyothong and Wanapat (2003) found no change in milk yields of crossbred dairy cows when 33% of the concentrate supplement was replaced by hay made from cassava foliage and the forage legume Stylosanthes guianensis CIAT 184. From an intensive grazing system with ad libitum access to high-quality pastures in California, USA, Daley et al (2010) reported no significant milk yield difference but higher IOFC per cow when reducing the concentrate supplementation levels from 24% (5.4 kg) to 12% (2.7 kg) of dry matter intake. McEvoy et al (2008) found no significantly lower milk production of spring-calving Holstein-Friesian cows in early lactation when reducing concentrate from 6 kg to 3 kg per cow per day as long as animals had access to a high-quality pasture. Vera (1990) investigated the effect of 50% substitution of commercial concentrate by soybean hay in growing heifers and reported a saving of 365 kg of concentrate, equivalent to about 100 $US/cow per year.

 

Supplementing cows feeding on tropical pasture grasses with protein is crucial to support animal performance, even during the rainy season due to limited levels of metabolizable protein in tropical grasses. This is particularly valid for the dry season when, in general, only poor-quality forages with low CP content and low digestibility are available. Juarez Lagunes et al (1999) evaluated the carbohydrate and protein fractions and corresponding rate of digestion of 15 tropical pasture grasses in Mexico using the Cornell Net Carbohydrate and Protein System to evaluate their ability to support milk production of dual-purpose cows. They showed that milk production increased by about 35% as CP increased from 8 to 12%.

 

The problem of oversupplementation with concentrates and underutilization of inexpensive forage resources was highlighted by Baars (1998) in Costa Rica and Lentes et al (2010b) in Honduras. The challenge is to reduce the expensive dependence on commercial concentrates by an appropriate use of conserved forage including legumes. As shown in this study, substituting commercial concentrate by farm-produced cowpea products can reduce feed costs and have a direct and significant effect on farmers’ income even though milk yields might be slightly lower. Khalili et al (1992) found that the milk yield of crossbred cows increased by 0.52 kg per cow and day per kg additional concentrate supplemented. Based on concentrate costs (0.17-0.27 $US/kg, depending on quality) and milk prices (0.29 $US/kg) in Honduras at the time of this study, milk yield increase should be at least 0.59-0.93 kg per kg additional concentrate to achieve an increase of IOFC.

 

Moreover, on-farm produced protein sources such as cowpea hay and grain are likely to have lower price fluctuations and be less dependent on international markets than concentrates based on imported ingredients. Costs of commercial feed concentrates are expected to increase even further, partly as a result of the increased demand for land and agricultural products, particularly maize, for biofuel production (FAO 2009).

 

Therefore, it is important to offer farmers alternatives such as forage legumes to be integrated in their production systems in order to remain competitive. Cowpea can be intercropped in maize and sorghum, or produced at the end of the rainy season, filling a niche that could contribute to additional food, feed and/or income generation of smallholders. The level to which protein sources should be supplemented needs to be adapted to the prevalent situation considering nutrient requirements of the cow throughout and between lactation periods, nutrient availability from grazed forages throughout the year, and the cost of supplements.

 

Brachiaria brizantha cv. Toledo silage and sorghum silage versus maize silage

 

Based on the results of this study, a farmer with 10 cows would save about 60 $US (Experiment 2a) and 648 $US (Experiment 2b) during a supplementation period of four dry-season months when substituting maize silage by Toledo silage and sorghum silage, respectively.

 

The Toledo silage in this study presented 25.6% DM and pH 5. According to Weissbach (2002), a pH £ 4.35 is required to permit favourable conditions for a stable silage whereas the risk of butyric acid fermentation increases in the case of grass silages with pH > 4.35. Though the risk of mal-fermentation with clostridia might have been high with the Toledo silage used in Experiment 2a, organoleptic evaluation indicated absence of butyric and strong acetic acid odour. One reason for the inhibition of butyric acid formation by clostridia could have been that Toledo was fertilized with nitrogen. The degradation product of nitrate, nitrite, is an inhibitor for the development of clostridia (Spoelstra 1985). Another reason could have been that due to the relatively long particle size of the chopped material and the rather coarse texture of Toledo grass, moisture was bound intracellularly and therefore had less influence on the fermentation process. Reiber et al (2009) showed that short wilting and the addition of sugar-containing additives, especially molasses, improved fermentation quality of B. brizantha cv. Toledo bag silage.

 

O’Mara et al (1998) examined the effects of replacing highly digestible grass silage by maize silage, on forage intake and milk production of Friesian cows. A proportion of one third maize silage (two thirds grass silage) was sufficient to achieve maximum milk yield. Kirchgessner et al (1981) found significantly higher milk production when grass silage and maize silage were mixed instead of feeding grass silage in the morning and maize silage in the evening. Keady et al (2008) showed that including maize silage in grass silage-based diets can improve milk output due to increased metabolizable energy intake. They calculated the potential concentrate-sparing effect to be as high as 3.4 kg/cow per day when maize silage is included in a 40% proportion as forage component of grass silage-based diets.

 

Results of Experiment 2b confirmed farmer’s previous observation that cows produced considerably more milk with sorghum silage than with maize silage. However, the reason why cows preferred sorghum silage to maize silage remains unclear since both silages were of similar quality.

 

The costs of sorghum silage per kilogram was slightly higher compared to maize silage mainly due to lower biomass production (17.1 tons FM/ha compared to 28.6 tons/ha). Sorghum biomass production in other nearby fields was 28-36 tons/ha whereas, under favourable conditions, total biomass production per year can exceed 100 tons. In this case, biomass production of sorghum was very low. Reasons include: a) sorghum had low plant density (50,000 plants/ha); b) whereas maize was fertilized with about 130 kg/ha NPK (18-46-0) and the same amount of urea, sorghum was fertilized only with about 130 kg/ha NPK; and c) water availability was different since sorghum was sown after maize in October (towards the end of the rainy season). Therefore, data of biomass production of sorghum and maize used in this case can not be directly compared and taken for further cost-benefit analyses.

 

The calculation of sorghum silage costs did not consider that sorghum re-sprouts and can be harvested another two times. Silage from the second (and third) cut is less expensive since land preparation and establishment costs are not included in its calculation. Assuming for the second cut a similar production of about 17 tons FM/ha, sorghum silage cost would be about 0.015 $US/kg FM, which is almost half of the cost of the first cut and lower than the cost of maize silage (0.025 $US/kg FM).

 

Many farmers in the region argued that they favoured sorghum silage rather than maize silage for the following reasons: a) sorghum can be harvested several times without need of re-cultivation, thus reducing production costs; b) after cutting sorghum, it re-sprouts rapidly whereas maize has to be replanted causing a delay in forage production; and c) sorghum, due to higher drought tolerance or (in case of re-growth) its already developed root system, produces biomass even well into the dry season, when maize does not grow any more. As an alternative strategy, sorghum could be harvested two to three times for silage, and the last cut could be supplemented fresh or as hay in the dry season. As a consequence of farmers’ observations, maize was being substituted by sorghum for silage in the Yoro region.


Conclusions and Recommendation


Acknowledgements

The authors gratefully acknowledge the financial support for this work by BMZ/GTZ (now GIZ, Gesellschaft für Internationale Zusammenarbeit). Special thanks go to the collaborating farmers Heraldo Cruz (Experiment 1a), Isidoro Murillo (Experiment 1b), Edwin Torres (Experiment 2a) and Teofilo Flores (Experiment 2b). Thanks to the Honduran Institute for Agricultural Research and Extension (Direccción de Ciencia y Tecnología Agropecuaria, DICTA) for the collaboration and provision of office facilities. We are grateful to Peter Lentes and Volker Hoffmann for their continuous support. Sincere thanks to Jens Möhring for his valuable statistical consulting service.


References

Akinlade J A, Smith J W, Raji A M, Busari A A, Adekunle I O and Adewumi M K 2005 Effect of two cowpea (Vigna unguiculata) fodder cultivars as supplements on voluntary intake, milk yield and manure production of Bunaji Cows. Journal of Agriculture and Rural Development in the Tropics and Subtropics 106 (2), 105–112

 

Anele U Y, Arigbede O M, Südekum K-H, Ike K A, Oni A O, Olanite J A, Amole G A, Dele P A and Jolaosho A O 2010 Effects of processed cowpea (Vigna unguiculata L. Walp) haulms as a feed supplement on voluntary intake, utilization and blood profile of West African dwarf sheep fed a basal diet of Pennisetum purpureum in the dry season. Animal Feed Science and Technology 159, 10-17

 

AOAC 1990 Official methods of analysis. Association of Official Analytical Chemists, Arlington, Virginia, 15th edition, 1298 pp.

 

Baars R M T 1998 Nutrition management, nitrogen efficiency, and income over feed cost on dairy farms in Costa Rica. Journal of Dairy Science 81 (3), 801-806

 

Baloyi J J, Ngongoni N T, Topps J H, Acamovic T and Hamudikuwanda H 2001 Condensed tannin and saponin content of Vigna unguiculata (L.) Walp, Desmodium uncinatum, Stylosanthes guianensis and Stylosanthes scabra grown in Zimbabwe. Tropical Animal Health and Production 33, 57-66

 

Bartholomew P W, Ly R, Doumbia M, Khibe T, Kone N'g, Traore B and Ba S 2003 Agro-industrial by-products, cowpea residues and urea-treatment of hay for supplementary dry season feeding of mature zebu oxen in Mali. Livestock Research for Rural Development 15 (2). Retrieved April 13, 2011, from http://www.lrrd.org/lrrd15/2/bart152.htm

 

Chakeredza S, Meulen U and Ndlovu L R 2002 Ruminal fermentation kinetics in ewes offered a maize stover basal diet supplemented with cowpea hay, groundnut hay, cotton seed meal or maize meal. Tropical Animal Health and Production 34 (3), 215-230

 

Daley C A, Horton S and Holmes D E 2010 Improving net profit under intensive grazing management. FAFO (Farmers Advocating For Organics) report, July 2010. California State University, Chico - Organic Dairy Farm.http://www.csuchico.edu/ag/farm/dairy-unit/photos-documents/fafo-study.pdf (03.04.2011)

 

Elanco Animal Health 1997 Body condition scoring in dairy cattle. Indianapolis, IN.

 

FAO 2009 The state of agricultural commodity markets 2009. High food prices and the food crisis – experiences and lessons learned. FAO, Rome, Italy.

 

Holmann F and Lascano C 2004 Feeding systems with forage legumes to intensify dairy production in Latin America and the Caribbean: A project executed by the Tropileche Consortium. CIAT (Centro Internacional de Agricultura Tropical), Tropileche Consortium, Cali, Colombia; SLP (System-wide Livestock Programme), Addis Ababa, Ethiopia; and ILRI (International Livestock Research Institute), Nairobi, Kenya. 172 pp.

 

IBM SPSS Statistics 19 Software 2010 Version 19.0. SPSS Inc., an IBM company, NY, USA.

 

Juarez Lagunes F I, Fox D G, Blake R W and Pell A N 1999 Evaluation of tropical grasses for milk production by dual-purpose cows in tropical Mexico. Journal of Dairy Science 82 (10), 2136-2145

 

Keady T W J, Kilpatrick D J, Mayne C S and Gordon F J 2008 Effects of replacing grass silage with maize silages, differing in maturity, on performance and potential concentrate sparing effect of dairy cows offered two feed value grass silages. Livestock Science 119, Issues 1-3, 1-11

 

Khalili H, Varvikko T and Crosse S 1992 The effects of forage type and level of concentrate supplementation on food intake, diet digestibility and milk production of crossbred cows (Bos taurus × Bos indicus). Animal Production 54, 183-189
 

Kirchgessner M, Schwarz F J and Lindner H P 1981 Feed consumption and performance of dairy cows with alternate feedings of grass silage and maize silage. Animal Feed Science and Technology 6 (4), 337-346
 

Kiyothong K and Wanapat M  2003 Cassava hay and Stylo 184 hay to replace concentrates in diets for lactating dairy cows. Livestock Research for Rural Development 15 (11). Retrieved April 12, 2011, from http://www.lrrd.org/lrrd15/11/krai1511.htm

 

Koralagama K D N, Mould F L, Fernandez-Rivera S and Hanson J 2008 The effect of supplementing maize stover with cowpea (Vigna unguiculata) haulms on the intake and growth performance of Ethiopian sheep. Animal 2, 954-961

 

Lentes P, Peters M and Holmann F 2010a Regionalization of climatic factors and income indicators for milk production in Honduras. Ecological Economics 69, 531-552

 

Lentes P, Holmann F, Peters M and White D 2010b Constraints, feeding strategies and opportunities to improve productivity and income in milk production systems in Olancho, Honduras. Tropical Grasslands 44, 33-46. Retrieved April 11, 2011, from http://www.tropicalgrasslands.asn.au/Tropical%20Grasslands%20Journal%20archive/PDFs/Vol_44%20(1_2_3_4)/Vol%2044%20(1)%20-%20Lentes%20et%20al%2033.pdf

 

Lucas H L 1960 Critical features of good dairy feeding experiments. Journal of Dairy Science 43 (2), 193-212 

Mannetje L ‘t 2000 Silage making in the tropics with particular emphasis on smallholders. Plant Production and Protection Paper No. 161. FAO, Rome. Retrieved April 8, 2011, from http://www.fao.org/docrep/005/x8486e/x8486e00.htm

 

McEvoy M E, Kennedy E, Murphy J P, Boland T M, Delaby L and O’Donovan M 2008 The effect of herbage allowance and concentrate supplementation on milk production performance and dry matter intake of spring-calving dairy cows in early lactation. Journal of Dairy Science 91, 1258-1269

 

Murthy U G K and Prasad J R 2002 Evaluation of legume hay based complete rations in sheep. Indian Journal of Animal Nutrition 19 (4), 315-319

 

Nakiganda A, Upton M, Phipps R, Mcleod A, Taylor N and Bua A 2005 Economics of feeding strategies in smallholder dairy cattle farming systems in central Uganda. African Crop Science Conference Proceedings 7, 767-769

 

ÖAG 1999 Silagebewertung nach Sinnenprüfung ÖAG Schlüssel, 1999. Österreichische Arbeitsgemeinschaft für Grünland und Futterbau. http://www.bundesforste.at/fileadmin/user_upload/Prdukte_Loesungen/Jagd_Fischerei/Silagebewertung_OEAG_1999.pdf (10.04.2011)

 

O’Mara F P, Fitzgerald J J, Murphy J J and Rath M 1998 The effect on milk production of replacing grass silage with maize silage in the diet of dairy cows. Livestock Production Science 55 (1), 79-87

 

Penn State University 2009 Dairy risk management education: managing income over feed costs. The Pennsylvania State University, USA. www.das.psu.edu/dairy-alliance/pdf/ManagingIOFC.pdf (27.03.2011)

 

Ravhuhali K E, Ng’ambi J W and Norris D 2010 Chemical composition and enzymatic in vitro digestibility of cowpea cultivars and buffalo grass hay grown in Limpopo province of South Africa. Livestock Research for Rural Development. Volume 22, Article #170. Retrieved April 11, 2011, from http://www.lrrd.org/lrrd22/9/ravh22170.htm

 

Reiber C, Schultze-Kraft R, Peters M and Hoffmann V 2009 Potential and constraints of little bag silage for smallholders – results and experiences from Honduras. Experimental Agriculture 45 (2), 209-220

 

Reiber C, Schultze-Kraft R, Peters M, Lentes P and Hoffmann V 2010 Promotion and adoption of silage technologies in drought-constrained areas of Honduras. Tropical Grasslands 44, 231-245. Retrieved April 11, 2011, from http://www.tropicalgrasslands.asn.au/Tropical%20Grasslands%20Journal%20archive/PDFs/Vol_44%20(1_2_3_4)/Vol%2044%20(4)%20Reiber%20et%20al%20231.pdf

 

Rivas-Vega M E, Goytortúa-Bores E, Ezquerra-Brauer J M, Salazar-Garcia M G, Cruz-Suárez L E, Nolasco H and Civera-Cerecedo R 2006 Nutritional value of cowpea Vigna unguiculata L. Walp meals as ingredients in diets for Pacific white shrimp Litopenaeus vannamei Boone. Food Chemistry 97, 41-49

 

Savadogo M, Zemmelink G, Nianogo A J and Van Keulen H 2000 Cowpea Vigna  unguiculata L. Walp and groundnut Arachys hypogea L. haulms as supplements to sorghum Sorghum bicolor L. Moench stover: Intake, digestibility and optimum feeding levels. Animal Feed Science and Technology 87, 57-69

 

Shelton H M, Franzel S and Peters M 2005 Adoption of tropical legume technology around the world: analysis of success. Tropical Grasslands 39, 198–209

 

Spoelstra S F 1985 Nitrate in silage. Grass and Forage Science 40, 1–11

 

Tempelman R J 2004 Experimental design and statistical methods for classical and bioequivalence hypothesis testing with an application to dairy nutrition studies. Journal of Animal Science 82 (E. Suppl.), E162–E172

 

Vera P A 1990 Efecto de la substitución de concentrado por heno de soya forrajera (Neonotonia wightii) en el crecimiento de novillas lecheras de reemplazo. Tesis. Escuela Agrícola Panamericana, Zamorano, Honduras. 36 pp.

 

Weissbach F 2002 Grundlagen und Praxis der Produktion guter Grassilagen. In: Bericht zum 8. Alpenländischen Expertenforum „Zeitgemäße Futterkonservierung“, BAL, Gumpenstein, Austria.



Received 16 April 2011; Accepted 4 July 2011; Published 3 August 2011

Go to top